ADSORPSI ASAM LEMAK BEBAS PADA CRUDE PALM OIL MENGGUNAKAN ZEOLIT TERAKTIVASI K2CO3

Nia Dahlia, Winda Rahmalia, Thamrin Usman

Abstract


Research on the use of K2CO3-activated zeolite as an adsorbent for free fatty acid (FFA) adsorption on crude palm oil (CPO) has been done. CPO is one of the mainstay products of Indonesian plantations which are used as raw material for cooking oil. The aim of this study to determine the adsorption capacity of activated zeolites against free fatty acid of CPO. The results showed that the iodium uptake capacity of zeolites before activation was 495.6%, activated zeolites were 527.1% and impregnated zeolites were 642.6%. The number of zeolites with the best absorption was 2 grams and ALB was absorbed 4.079% for activated zeolites (ZAA), 4.98% for impregnated zeolites (ZAI), and the water content and impurities were still below SNI standards. The CPO adsorption process with zeolites shows the Langmuir model with a correlation value (R2) of 0.9999 for ZAA and (R2) of 0.9976 for ZAI. The results showed that activated zeolites had lower absorption than impregnated zeolites.

Full Text:

PDF

References


Badan Pusat Statistik, 2016, Statistik Kelapa Sawit Indonesia, Badan Pusat Statistik, Jakarta

Direktorat Perkebunan, 2016, Statistik Perkebunan Indonesia, 2014-2016 : Kelapa Sawit (Oil Palm), Skretariat Dirktorat Jenderal Perkebunan, Jakarta

Sunarno, dan Silvia, R.Y., 2013, Pembuatan Zeolit Sintesis dan Aplikasinya Sebagai Katalis pada Cracking Cangkang Sawit menjadi Bio-Oil, Jurnal Eknobiologi, Vol IV (1): 35-39

Rifin, A., 2017, Efesiensi Perusahaan Crude Palm Oil (CPO) di Indonesia, Jurnal Manajemen & Agribisnis, Vol 14 (2)

Kurniati, Y., dan Wahono, H.S., 2015, Pengaruh Basa dan NaOH dan Kandungan ALB CPO terhadap Kualitas Minyak Kelapa Sawit Pasca Netralisasi, Jurnal Pangan dan Agroindustri, Vol 3 (1)

Adanan, I., 2012, Pengaruh Waktu Penyimpanan CPO Terhadap Kenaikan Asam Lemak Bebas (ALB) pada Oil Tank, Oil Purifier dan Vacum Dryer, Tesis

Widi, A.M., Amin, dan Aprimal, 2006, Pemucatan Minyak Kelapa Sawit (CPO) dengan cara Adsorbsi Menggunakan Zeolit Alam Lempung, Jurnal Zeolit Indonesia, 5 (2)

Yuanita, L.D., 2010, Kajian Modifikasi dan Karakterisasi Zeolit Alam dari Berbagai Negara, Jurdik Kimia, UNY

Yunita, D., 2009, Hidrogenasi Katalitik Metil Oleat Menjadi Stearil Alkohol Menggunkan Katalis Ni/Zeolit Alam, Prosiding Seminar Nasional Kimia UNY

Ertan, A., and Ozkan, 2005, CO2 and N2 Adsorption on the Acid (HCl, HNO3, H2SO4, and H3PO4) Treated Zeolites, Adsorption, 11: 151-156

Laeli, K.M., Djaeni, dan Aplilina, P., 2011, Aktivitas Zeolit Alam Sebagai Adsorben pada Alat Pengering Bersuhu Rendah, Reaktor, V0l 13 (3) : 178-184

Handoyo, R., Heri, P., Siti, S., Iis, N., Nita, Y., Amelia, R., dan Ratna, K., 2005, Peningkatan Rasio Si/Al Zeolit Alam Mordenit sebagai Bahan Dasar Zeolit Katalis, Jurnal Zeolit Indonesia, Vol 4 (1)

Anwar, D.I., 2011, Sintesis Komposit Fe-TiO2-SiO2 sebagai Fotokatalisis pada Degradasi Erionyl Yellow, Tesis, Fakultas Matematika dan Ilmu Pengetahuan Alam Universitas Gajah Mada, Yogyakarta

Zuhriah, S., 2011, Degradasi Zat Warna Methyl Orange menggunakan Fotokatalis ZnO-Zeolit dengan Sinar UV, Skripsi, FMIPA Universitas Brawijaya, Malang

Farradina, C.S., 2015, Adsorpsi Hidrogen pada Material Karbon Tertemplat Zeolit-Y dengan Aktivasi K2CO3, Tesis

Prasetyo, A., Rini, N., Susi, N.K., dan Agie, B., 2012, Analisis Permukaan Zeolit Alam Malang yang Mengalami Modifikasi Pori dengan Uji SEM-EDS, Sainstis, 1 (2): 2089-0699

Lalang, B.R., Suci, A., dan Susi, N.K., 2012, Pengaruh Impregnasi Logam Titanium pada Zeolit Alam Malang Terhadap Luas Permukaan Zeolit, Alchemy, Vol 2 (1)

Alfiany, H., Bahri, S., dan Nurakhirawati, 2013, Kajia Penggunaan Arang Aktif Tongkol Jagung Sebagai Adsorben Logam Pb dengan Beberapa Aktivator Asam, Jurnal Natural Science, vol 2 (3)

Safi’i, F.F., dan Minarlis, 2013, Pemanfaatan Limbah Padat Proses Sintesis Pembuatan Furfural dari Sekam Padi Sebagai Arang Aktif, Journal of Chemistry, Vol 2 (2)

SNI, 2006, Standar Nasional Indonesia Minyak Kelapa Sawit Mentah (Crude Palm Oil) 01-2901-2006, BSN, Jakarta

Sopianti, D.S., Herlina, Handi, T.S., 2017, Penetapan Kadar Asam Lemak Bebas pada Minyak Goreng, Jurnal Katalisator, Vol 2 (2)

Ngado, E., 2013, Some Quality Parameters of Crude Palm Oil from Major Markets of Douala, Cameroon, African Journal of Food Sciene, Vol 7: 473-478

Rasaouli, M., Yaghobi, N., and Hafezi, M., 2012, Journal of Industrial and Engineering Chemistry, 18, 1970-1976




DOI: http://dx.doi.org/10.26418/indonesian.v2i3.36892

Refbacks

  • There are currently no refbacks.


Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.

------------------------------------------------------------------------------

Indonesian Journal of Pure and Applied Chemistry (IJoPAC)

p-ISSN : 2620-8571, e-ISSN : 2620-858X5

Office Address:

Department of Chemistry, Faculty of Mathematics and Natural Sciences, University of Tanjungpura, Jl. Prof. Dr. Hadari Nawawi, Pontianak, Indonesia 78124

Contact Person: +6289644694946, +6281236728813

Email: [email protected]

Supported by: